The chevy volt pack can be broken up into small packs.
In my case a 48 Volt 45 Ah module or maybe 2 to get 48 Volt 90Ah.
My boat is an older (1979) trihull boat(not the best efficiency)
I had a 75 Hp outboard with a dead motor.
From what I have read here a larger prop is better.
I hope mine isn't to large for the motor.
I currently have a direct connection with a lovejoy connector.
Maybe I should consider a pulley so I can change ratios if I get too much heat.
I think it is a 4 to 1 ratio.
I don't plan on going to fast(4-5 knot) and my range doesn't need to be too much( 2-3 miles).
--------------------------------------------
On Wed, 2/3/16, Bill and Ai Qiu hopen billhopen@yahoo.com [electricboats] <electricboats@yahoogroups.com> wrote:
Subject: Re: [Electric Boats] Re: using a 36 Volt dc motor from a 48 volt pack
To: electricboats@yahoogroups.com
Received: Wednesday, February 3, 2016, 8:30 PM
wow thats
big power....what are you pushing with that? the size and
pitch of prop/transmission/rpm have to be right to keep
from over-heating on long runs. throw in a temp gauge or
a small fan blowing on the armature/brushes
area
Bill Hopen - www.billhopen.com
Hopen Studio Inc - 227 Main St.,
Sutton WV 26601
304 -765-5611
billhopen@yahoo.com
From: "Mark F
mark.internet@yahoo.ca [electricboats]"
<electricboats@yahoogroups.com>
To:
electricboats@yahoogroups.com
Sent: Wednesday,
February 3, 2016 10:16 PM
Subject: Re: [Electric
Boats] Re: using a 36 Volt dc motor from a 48 volt pack
I have a
48 Volt battery module from a chevy volt, I plan on charging
it with some solar panels.
I have a 36 Volt Golf cart motor(1960's vintage)
attached to a chrysler 75 Hp outboard motor leg.
I am considering an altrax sepex controller.
My motor is a 36 volt DC sepex motor.
Like you say worst case I fry the motor.
--------------------------------------------
On Wed, 2/3/16, king_of_neworleans
<no_reply@yahoogroups.com> wrote:
Subject: [Electric Boats] Re: using a 36 Volt dc motor from
a 48 volt pack
To: electricboats@yahoogroups.com
Received: Wednesday, February 3, 2016, 5:28 PM
Sure. Overvolting most DC motors by a modest
amount usually won't cause a catastrophic failure,
though it might reduce lifespan of the motor through
degradation of the coil insulation. Not covered, is
overvolting, by warranty. You should have a temp sensor
installed and an overtemp shutdown system. I know my
cheapie
Kelly controller shuts down at a certain temp if I enable
it
and connect a thermistor, which I haven't by the way
but
should. If the motor is not exceeding max operating temp
you
are good to go. Just in case, you might want to have a
spare
motor. No biggie because usually the motor is the
cheapest
component. My controller cost twice what my motor cost.
My
battery bank cost almost 3x what my motor cost. Even my
reduction gear cost more than my motor. So, I have two
of
them. Three, actually, since I bought a 12kw motor to
play
around with. My regular motor is 5kw. Anyway, as long as
you
take proper precautions I don't see a problem. And
with
a spare motor you are set for any uh-oh moments.
BTW, this opinion is
guaranteed to be worth a minimum of what you paid for
it.
IOW, YMMV. But FWIW, I will be doing exactly the same
thing
with my trolling motor powered pirogue, running off a
Chinese 48v PWM controller and 48v lithium e-bike
battery.
The trolling motor is 12v, actually. I don't think
it
will be a problem. If it is, I burn up a $130 trolling
motor
and have to paddle back to the boat. Obviously I will not
be
running it at full available power from the controller,
but
it should work okay.
Is
your motor brushed, or brushless?
#yiv2236444180 #yiv2236444180 --
#yiv2236444180ygrp-mkp {
border:1px solid #d8d8d8;font-family:Arial;margin:10px
0;padding:0 10px;}
#yiv2236444180 #yiv2236444180ygrp-mkp hr {
border:1px solid #d8d8d8;}
#yiv2236444180 #yiv2236444180ygrp-mkp #yiv2236444180hd {
color:#628c2a;font-size:85%;font-weight:700;line-height:122%;margin:10px
0;}
#yiv2236444180 #yiv2236444180ygrp-mkp #yiv2236444180ads
{
margin-bottom:10px;}
#yiv2236444180 #yiv2236444180ygrp-mkp .yiv2236444180ad {
padding:0 0;}
#yiv2236444180 #yiv2236444180ygrp-mkp .yiv2236444180ad p
{
margin:0;}
#yiv2236444180 #yiv2236444180ygrp-mkp .yiv2236444180ad a
{
color:#0000ff;text-decoration:none;}
#yiv2236444180 #yiv2236444180ygrp-sponsor
#yiv2236444180ygrp-lc {
font-family:Arial;}
#yiv2236444180 #yiv2236444180ygrp-sponsor
#yiv2236444180ygrp-lc #yiv2236444180hd {
margin:10px
0px;font-weight:700;font-size:78%;line-height:122%;}
#yiv2236444180 #yiv2236444180ygrp-sponsor
#yiv2236444180ygrp-lc .yiv2236444180ad {
margin-bottom:10px;padding:0 0;}
#yiv2236444180 #yiv2236444180actions {
font-family:Verdana;font-size:11px;padding:10px 0;}
#yiv2236444180 #yiv2236444180activity {
background-color:#e0ecee;float:left;font-family:Verdana;font-size:10px;padding:10px;}
#yiv2236444180 #yiv2236444180activity span {
font-weight:700;}
#yiv2236444180 #yiv2236444180activity span:first-child {
text-transform:uppercase;}
#yiv2236444180 #yiv2236444180activity span a {
color:#5085b6;text-decoration:none;}
#yiv2236444180 #yiv2236444180activity span span {
color:#ff7900;}
#yiv2236444180 #yiv2236444180activity span
.yiv2236444180underline {
text-decoration:underline;}
#yiv2236444180 .yiv2236444180attach {
clear:both;display:table;font-family:Arial;font-size:12px;padding:10px
0;width:400px;}
#yiv2236444180 .yiv2236444180attach div a {
text-decoration:none;}
#yiv2236444180 .yiv2236444180attach img {
border:none;padding-right:5px;}
#yiv2236444180 .yiv2236444180attach label {
display:block;margin-bottom:5px;}
#yiv2236444180 .yiv2236444180attach label a {
text-decoration:none;}
#yiv2236444180 blockquote {
margin:0 0 0 4px;}
#yiv2236444180 .yiv2236444180bold {
font-family:Arial;font-size:13px;font-weight:700;}
#yiv2236444180 .yiv2236444180bold a {
text-decoration:none;}
#yiv2236444180 dd.yiv2236444180last p a {
font-family:Verdana;font-weight:700;}
#yiv2236444180 dd.yiv2236444180last p span {
margin-right:10px;font-family:Verdana;font-weight:700;}
#yiv2236444180 dd.yiv2236444180last p
span.yiv2236444180yshortcuts {
margin-right:0;}
#yiv2236444180 div.yiv2236444180attach-table div div a {
text-decoration:none;}
#yiv2236444180 div.yiv2236444180attach-table {
width:400px;}
#yiv2236444180 div.yiv2236444180file-title a,
#yiv2236444180
div.yiv2236444180file-title a:active, #yiv2236444180
div.yiv2236444180file-title a:hover, #yiv2236444180
div.yiv2236444180file-title a:visited {
text-decoration:none;}
#yiv2236444180 div.yiv2236444180photo-title a,
#yiv2236444180 div.yiv2236444180photo-title a:active,
#yiv2236444180 div.yiv2236444180photo-title a:hover,
#yiv2236444180 div.yiv2236444180photo-title a:visited {
text-decoration:none;}
#yiv2236444180 div#yiv2236444180ygrp-mlmsg
#yiv2236444180ygrp-msg p a span.yiv2236444180yshortcuts
{
font-family:Verdana;font-size:10px;font-weight:normal;}
#yiv2236444180 .yiv2236444180green {
color:#628c2a;}
#yiv2236444180 .yiv2236444180MsoNormal {
margin:0 0 0 0;}
#yiv2236444180 o {
font-size:0;}
#yiv2236444180 #yiv2236444180photos div {
float:left;width:72px;}
#yiv2236444180 #yiv2236444180photos div div {
border:1px solid
#666666;height:62px;overflow:hidden;width:62px;}
#yiv2236444180 #yiv2236444180photos div label {
color:#666666;font-size:10px;overflow:hidden;text-align:center;white-space:nowrap;width:64px;}
#yiv2236444180 #yiv2236444180reco-category {
font-size:77%;}
#yiv2236444180 #yiv2236444180reco-desc {
font-size:77%;}
#yiv2236444180 .yiv2236444180replbq {
margin:4px;}
#yiv2236444180 #yiv2236444180ygrp-actbar div a:first-child
{
margin-right:2px;padding-right:5px;}
#yiv2236444180 #yiv2236444180ygrp-mlmsg {
font-size:13px;font-family:Arial, helvetica, clean,
sans-serif;}
#yiv2236444180 #yiv2236444180ygrp-mlmsg table {
font-size:inherit;font:100%;}
#yiv2236444180 #yiv2236444180ygrp-mlmsg select,
#yiv2236444180 input, #yiv2236444180 textarea {
font:99% Arial, Helvetica, clean, sans-serif;}
#yiv2236444180 #yiv2236444180ygrp-mlmsg pre,
#yiv2236444180
code {
font:115% monospace;}
#yiv2236444180 #yiv2236444180ygrp-mlmsg * {
line-height:1.22em;}
#yiv2236444180 #yiv2236444180ygrp-mlmsg #yiv2236444180logo
{
padding-bottom:10px;}
#yiv2236444180 #yiv2236444180ygrp-msg p a {
font-family:Verdana;}
#yiv2236444180 #yiv2236444180ygrp-msg
p#yiv2236444180attach-count span {
color:#1E66AE;font-weight:700;}
#yiv2236444180 #yiv2236444180ygrp-reco
#yiv2236444180reco-head {
color:#ff7900;font-weight:700;}
#yiv2236444180 #yiv2236444180ygrp-reco {
margin-bottom:20px;padding:0px;}
#yiv2236444180 #yiv2236444180ygrp-sponsor
#yiv2236444180ov
li a {
font-size:130%;text-decoration:none;}
#yiv2236444180 #yiv2236444180ygrp-sponsor
#yiv2236444180ov
li {
font-size:77%;list-style-type:square;padding:6px 0;}
#yiv2236444180 #yiv2236444180ygrp-sponsor
#yiv2236444180ov
ul {
margin:0;padding:0 0 0 8px;}
#yiv2236444180 #yiv2236444180ygrp-text {
font-family:Georgia;}
#yiv2236444180 #yiv2236444180ygrp-text p {
margin:0 0 1em 0;}
#yiv2236444180 #yiv2236444180ygrp-text tt {
font-size:120%;}
#yiv2236444180 #yiv2236444180ygrp-vital ul li:last-child
{
border-right:none !important;
}
#yiv2236444180
#yiv5798235126 #yiv5798235126 --
#yiv5798235126ygrp-mkp {
border:1px solid #d8d8d8;font-family:Arial;margin:10px
0;padding:0 10px;}
#yiv5798235126 #yiv5798235126ygrp-mkp hr {
border:1px solid #d8d8d8;}
#yiv5798235126 #yiv5798235126ygrp-mkp #yiv5798235126hd {
color:#628c2a;font-size:85%;font-weight:700;line-height:122%;margin:10px
0;}
#yiv5798235126 #yiv5798235126ygrp-mkp #yiv5798235126ads {
margin-bottom:10px;}
#yiv5798235126 #yiv5798235126ygrp-mkp .yiv5798235126ad {
padding:0 0;}
#yiv5798235126 #yiv5798235126ygrp-mkp .yiv5798235126ad p {
margin:0;}
#yiv5798235126 #yiv5798235126ygrp-mkp .yiv5798235126ad a {
color:#0000ff;text-decoration:none;}
#yiv5798235126 #yiv5798235126ygrp-sponsor
#yiv5798235126ygrp-lc {
font-family:Arial;}
#yiv5798235126 #yiv5798235126ygrp-sponsor
#yiv5798235126ygrp-lc #yiv5798235126hd {
margin:10px
0px;font-weight:700;font-size:78%;line-height:122%;}
#yiv5798235126 #yiv5798235126ygrp-sponsor
#yiv5798235126ygrp-lc .yiv5798235126ad {
margin-bottom:10px;padding:0 0;}
#yiv5798235126 #yiv5798235126actions {
font-family:Verdana;font-size:11px;padding:10px 0;}
#yiv5798235126 #yiv5798235126activity {
background-color:#e0ecee;float:left;font-family:Verdana;font-size:10px;padding:10px;}
#yiv5798235126 #yiv5798235126activity span {
font-weight:700;}
#yiv5798235126 #yiv5798235126activity span:first-child {
text-transform:uppercase;}
#yiv5798235126 #yiv5798235126activity span a {
color:#5085b6;text-decoration:none;}
#yiv5798235126 #yiv5798235126activity span span {
color:#ff7900;}
#yiv5798235126 #yiv5798235126activity span
.yiv5798235126underline {
text-decoration:underline;}
#yiv5798235126 .yiv5798235126attach {
clear:both;display:table;font-family:Arial;font-size:12px;padding:10px
0;width:400px;}
#yiv5798235126 .yiv5798235126attach div a {
text-decoration:none;}
#yiv5798235126 .yiv5798235126attach img {
border:none;padding-right:5px;}
#yiv5798235126 .yiv5798235126attach label {
display:block;margin-bottom:5px;}
#yiv5798235126 .yiv5798235126attach label a {
text-decoration:none;}
#yiv5798235126 blockquote {
margin:0 0 0 4px;}
#yiv5798235126 .yiv5798235126bold {
font-family:Arial;font-size:13px;font-weight:700;}
#yiv5798235126 .yiv5798235126bold a {
text-decoration:none;}
#yiv5798235126 dd.yiv5798235126last p a {
font-family:Verdana;font-weight:700;}
#yiv5798235126 dd.yiv5798235126last p span {
margin-right:10px;font-family:Verdana;font-weight:700;}
#yiv5798235126 dd.yiv5798235126last p
span.yiv5798235126yshortcuts {
margin-right:0;}
#yiv5798235126 div.yiv5798235126attach-table div div a {
text-decoration:none;}
#yiv5798235126 div.yiv5798235126attach-table {
width:400px;}
#yiv5798235126 div.yiv5798235126file-title a, #yiv5798235126
div.yiv5798235126file-title a:active, #yiv5798235126
div.yiv5798235126file-title a:hover, #yiv5798235126
div.yiv5798235126file-title a:visited {
text-decoration:none;}
#yiv5798235126 div.yiv5798235126photo-title a,
#yiv5798235126 div.yiv5798235126photo-title a:active,
#yiv5798235126 div.yiv5798235126photo-title a:hover,
#yiv5798235126 div.yiv5798235126photo-title a:visited {
text-decoration:none;}
#yiv5798235126 div#yiv5798235126ygrp-mlmsg
#yiv5798235126ygrp-msg p a span.yiv5798235126yshortcuts {
font-family:Verdana;font-size:10px;font-weight:normal;}
#yiv5798235126 .yiv5798235126green {
color:#628c2a;}
#yiv5798235126 .yiv5798235126MsoNormal {
margin:0 0 0 0;}
#yiv5798235126 o {
font-size:0;}
#yiv5798235126 #yiv5798235126photos div {
float:left;width:72px;}
#yiv5798235126 #yiv5798235126photos div div {
border:1px solid
#666666;height:62px;overflow:hidden;width:62px;}
#yiv5798235126 #yiv5798235126photos div label {
color:#666666;font-size:10px;overflow:hidden;text-align:center;white-space:nowrap;width:64px;}
#yiv5798235126 #yiv5798235126reco-category {
font-size:77%;}
#yiv5798235126 #yiv5798235126reco-desc {
font-size:77%;}
#yiv5798235126 .yiv5798235126replbq {
margin:4px;}
#yiv5798235126 #yiv5798235126ygrp-actbar div a:first-child {
margin-right:2px;padding-right:5px;}
#yiv5798235126 #yiv5798235126ygrp-mlmsg {
font-size:13px;font-family:Arial, helvetica, clean,
sans-serif;}
#yiv5798235126 #yiv5798235126ygrp-mlmsg table {
font-size:inherit;font:100%;}
#yiv5798235126 #yiv5798235126ygrp-mlmsg select,
#yiv5798235126 input, #yiv5798235126 textarea {
font:99% Arial, Helvetica, clean, sans-serif;}
#yiv5798235126 #yiv5798235126ygrp-mlmsg pre, #yiv5798235126
code {
font:115% monospace;}
#yiv5798235126 #yiv5798235126ygrp-mlmsg * {
line-height:1.22em;}
#yiv5798235126 #yiv5798235126ygrp-mlmsg #yiv5798235126logo {
padding-bottom:10px;}
#yiv5798235126 #yiv5798235126ygrp-msg p a {
font-family:Verdana;}
#yiv5798235126 #yiv5798235126ygrp-msg
p#yiv5798235126attach-count span {
color:#1E66AE;font-weight:700;}
#yiv5798235126 #yiv5798235126ygrp-reco
#yiv5798235126reco-head {
color:#ff7900;font-weight:700;}
#yiv5798235126 #yiv5798235126ygrp-reco {
margin-bottom:20px;padding:0px;}
#yiv5798235126 #yiv5798235126ygrp-sponsor #yiv5798235126ov
li a {
font-size:130%;text-decoration:none;}
#yiv5798235126 #yiv5798235126ygrp-sponsor #yiv5798235126ov
li {
font-size:77%;list-style-type:square;padding:6px 0;}
#yiv5798235126 #yiv5798235126ygrp-sponsor #yiv5798235126ov
ul {
margin:0;padding:0 0 0 8px;}
#yiv5798235126 #yiv5798235126ygrp-text {
font-family:Georgia;}
#yiv5798235126 #yiv5798235126ygrp-text p {
margin:0 0 1em 0;}
#yiv5798235126 #yiv5798235126ygrp-text tt {
font-size:120%;}
#yiv5798235126 #yiv5798235126ygrp-vital ul li:last-child {
border-right:none !important;
}
#yiv5798235126
Posted by: Mark F <mark.internet@yahoo.ca>
Reply via web post | • | Reply to sender | • | Reply to group | • | Start a New Topic | • | Messages in this topic (7) |
No comments:
Post a Comment